OEM Part NO. 2G-8000 / 2G8000 HARNESS ASSEMBLY

HOME :: Parts EPC :: OEM Part NO. 2G-8000 / 2G8000 HARNESS ASSEMBLY

Product Name: 2G8000HARNESS ASSEMBLY

Model: 16G Motor Grader

Section: Starting And Electric System

Group: 16G MOTOR GRADER 3406 ENGINE

Note: 2G8000 HARNESS ASSEMBLY--Part 2 of 2Serial No. 93U1179 to 93U1868 inclusivePart of 2G7616 Battery and Wiring Group shown on Pages 89, 91C, 91H, 91N & 91T

Get a Quote

Description

Product Name: 2G8000HARNESS ASSEMBLY

Category: Electric System

Remark: 2G8000 HARNESS ASSEMBLY--Part 2 of 2Serial No. 93U1179 to 93U1868 inclusivePart of 2G7616 Battery and Wiring Group shown on Pages 89, 91C, 91H, 91N & 91T

Model: 16G Motor Grader

Section: Array

Group: 16G MOTOR GRADER 3406 ENGINE

Is service: Y

CCR: Y

Is Filter: N

Is Maint: N

NPR: Y

IE type: I

Is arrangement: N

Is change: N

SEQPart NO.NamePos.Qty.NPRCCRServiceChangeTypeModifer

15P4571OEM Part NO. 5P-4571 / 5P4571 TERMINAL (To Flasher Unit & Turn Signal Switch)- / -7YNY--14-GA TO 16-GA
26D9404OEM Part NO. 6D-9404 / 6D9404 TERMINAL (Used with No. 6 Screw)- / -9YYY--NO. 6 SCREW
32D8757OEM Part NO. 2D-8757 / 2D8757 TERMINAL (DARK GREEN WIRE)- / -1YYY--SMALL
43K8671OEM Part NO. 3K-8671 / 3K8671 TERMINAL (8 GAUGE) 12.7MM(.5IN) SCREW- / -1YNY--LARGE
57D1314OEM Part NO. 7D-1314 / 7D1314 TERMINAL (ORANGE WIRE)- / -1YYY--TERMINAL
64S1988OEM Part NO. 4S-1988 / 4S1988 TERMINAL 23.5 mm(.925 in.) long- / -1YNY--14-GA TO 16-GA
72L8057OEM Part NO. 2L-8057 / 2L8057 TERMINAL (used with No. 8 wire)- / -1YNY--8-GA, NO. 10 SCREW
82L8049OEM Part NO. 2L-8049 / 2L8049 TERMINAL-RING 6 GA. (NO. 10 SCREW)- / -1YNY--6-GA, NO. 10 SCREW
95P5622OEM Part NO. 5P-5622 / 5P5622 *10 GAUGE 384CM 6V3381-18 GAUGE- / --YYY--.2M
105P5623OEM Part NO. 5P-5623 / 5P5623 WIRE .35M(13.780IN) TRAVEL ALARM HORN/GND CONTACT- / --YYY--16 GA
116N9587OEM Part NO. 6N-9587 / 6N9587 BULLET CONNECTOR (ETHER VALVE WIRES)- / -3YYY--MALE
125P5610OEM Part NO. 5P-5610 / 5P5610 CONNECTOR 2.1 cm(.827 in.) long- / -1YNY--FEMALE
135P5624OEM Part NO. 5P-5624 / 5P5624 WIRE 3.59M(141.340IN)(MICRO SWITCH LOCK OUT/STARTERRELAY)- / --YYY--.13M
145P5689OEM Part NO. 5P-5689 / 5P5689 WIRE-(NO. 8 GAUGE)-13 M (43 FOOT) *- / --YYY--WIRE
152L8075OEM Part NO. 2L-8075 / 2L8075 TERMINAL (To Rear Signal, Brake & Tail Lamp - R.H.)- / -4YNY--14-GA TO 16-GA, NO. 8 SCREW
162L8076OEM Part NO. 2L-8076 / 2L8076 TERMINAL (To Alternater Position F & E Terminal)- / -5YNY--14-GA TO 16-GA, NO. 10 SCREW
172L8066OEM Part NO. 2L-8066 / 2L8066 TERMINAL (NO. 10 SCREW) (USED WITH NO. 10 WIRE)- / -1YNY--4.83MM SCREW

SEQPart NO.NamePos.Qty.NPRCCRServiceChangeTypeModifer

13B4501OEM Part NO. 3B-4501 / 3B4501 LOCKWASHER (Part of 3F3099 Switch)- / -1YYY--1.02MM THK
23S2093OEM Part NO. 3S-2093 / 3S2093 STRAP-CABLE-TO TIE HARNESSES TOGETHER- / -6YYY--1.75IN DIA
37N5876OEM Part NO. 7N-5876 / 7N5876 LAMP-MINIATURE (28 VOLT)- / -4YYY--28 VOLT
49D3127OEM Part NO. 9D-3127 / 9D3127 BASE INDICATOR LIGHT TO STEERING CONSOLE- / -4YYY--EACH INCLUDES
59D2868OEM Part NO. 9D-2868 / 9D2868 LENS (red)- / -4YYY--FUEL PUMP ON INDICATOR
65P1076OEM Part NO. 5P-1076 / 5P1076 WASHER guard to support assembly and guard assembly- / -8YNY--4MM THK
78M2772OEM Part NO. 8M-2772 / 8M2772 CLIP (for 12.70 mm(.50 in.) hose- / -6YYY--6.35MM ID
85K8451OEM Part NO. 5K-8451 / 5K8451 CLIP 25.4 mm (1 in.) wide- / -4YYY--LOOP 15.88MM ID
95P5623OEM Part NO. 5P-5623 / 5P5623 WIRE .35M(13.780IN) TRAVEL ALARM HORN/GND CONTACT- / --YYY--16 GA
100S1594OEM Part NO. 0S-1594 / 0S1594 BOLT--FASTENING OF 1V3461 PLATE ASSEM. TO THE KICKPLATE- / -1YNY--3/8-16X1IN
110S0509OEM Part NO. 0S-0509 / 0S0509 BOLT--BETWEEN CASE AND SUPPORT OF LOADER FRAME (L.H. & R.H.)- / -3YNY--BOLT
124B4278OEM Part NO. 4B-4278 / 4B4278 WASHER (Not shown -- bottom of Battery Box to L.H. Fender)- / -1YYY--LARGE
131D4572OEM Part NO. 1D-4572 / 1D4572 BOLT 13.97 cm(5.5 in.)long-Location "A"- / -8YNY--1/2-13X5.5-IN
140T0102OEM Part NO. 0T-0102 / 0T0102 BOLT (.375" diameter-.625" long)- / -2YNY--3/8-16X0.625-IN
151B4330OEM Part NO. 1B-4330 / 1B4330 NUT FLAME ARRESTOR OR AIR CLEANER SCREWS- / -2YNY--1/4-20-THD
165P0747OEM Part NO. 5P-0747 / 5P0747 CABLE 286.70 cm(114.50 in.)- / --YYY--00-GA, BLACK 40-CM
171M6119OEM Part NO. 1M-6119 / 1M6119 BOLT-BATTERY TERMINAL (5/16-18X1.375IN)- / -1YYY--5/16-18X1.375-IN
181M6120OEM Part NO. 1M-6120 / 1M6120 NUT-BATTERY TERMINAL (5/16-18 THD)- / -1YYY--5/16-18-THD
194S9219OEM Part NO. 4S-9219 / 4S9219 BATTERY (220 amp)- / -2YYY---
201S7251OEM Part NO. 1S-7251 / 1S7251 TERMINAL 12.7 mm(.500 in.)bolt- / -1YNY--00-GA, 1/2-IN SCREW
212D1959OEM Part NO. 2D-1959 / 2D1959 BULB (Part of 3A1142 Assem.)- / -1YYY--MINIATURE
227S6402OEM Part NO. 7S-6402 / 7S6402 SWITCH ASSEM. (head & tail light)- / -1YYYNI3 POSITION
237S5432OEM Part NO. 7S-5432 / 7S5432 KNOB (Part of 7S6402 Assem.)- / -1YYY---
248S7713OEM Part NO. 8S-7713 / 8S7713 SWITCH ASSEM. (heat & start)- / -1YYYNIHEAT-START
258F3437OEM Part NO. 8F-3437 / 8F3437 LEVER (Part of 2S2342 Assem.)- / -1YYY--DISCONNECT
265L7200OEM Part NO. 5L-7200 / 5L7200 SCREW (Part of 2S2342 Assem.)- / -1YNY--8-32X0.375-IN
275M6668OEM Part NO. 5M-6668 / 5M6668 SCREW-MACHINE (8-32X.75IN)- / -2YNY--8-32X0.75-IN
287N0718OEM Part NO. 7N-0718 / 7N0718 SWITCH ASSEM. (To Disconnect)- / -1YYYNIDISCONNECT
292L8075OEM Part NO. 2L-8075 / 2L8075 TERMINAL (To Rear Signal, Brake & Tail Lamp - R.H.)- / -1YNY--14-GA TO 16-GA, NO. 8 SCREW
309F5644LOCKWASHER (Shakeproof)- / -1YYY--9.93MM ID
318H0878OEM Part NO. 8H-0878 / 8H0878 WASHER-LOCK- / -2YYY---
324B2043OEM Part NO. 4B-2043 / 4B2043 NUT (Part of 9F3099 Switch)- / -2YNY--8-32-THD
335P5689OEM Part NO. 5P-5689 / 5P5689 WIRE-(NO. 8 GAUGE)-13 M (43 FOOT) *- / --YYY--WIRE
349S0173OEM Part NO. 9S-0173 / 9S0173 CIRCUIT BREAKER (60 Amp - To Dash)- / -1YYY--CIRCUIT BREAKER
354D7794OEM Part NO. 4D-7794 / 4D7794 CLIP-- COMPRESSOR CLUTCH WIRE TO COMPRESSOR BODY- / -1YYY--10MM ID
365P1075OEM Part NO. 5P-1075 / 5P1075 WASHER (Plate to top of Front Bracket)- / -2YNY--10.2X22.5X3-MM THK
378M0537OEM Part NO. 8M-0537 / 8M0537 TERMINAL (Solder - Ground)- / -1YYY--LARGE
380S1616OEM Part NO. 0S-1616 / 0S1616 CAP SCREW BASIC GOVERNOR GROUP NOT SERVICED- / -2YNY--1/4-20X1IN LG
395P4571OEM Part NO. 5P-4571 / 5P4571 TERMINAL (To Flasher Unit & Turn Signal Switch)- / -1YNY--14-GA TO 16-GA
409M8406OEM Part NO. 9M-8406 / 9M8406 CLIP-TO 8X7433 HARNESS AS ON FORE-AFT- / -1YYY--LOOP
414L3916OEM Part NO. 4L-3916 / 4L3916 TERMINAL (Dark Blue and Dark Green Wire)- / -1YYY--14-GA TO 16-GA
422L8049OEM Part NO. 2L-8049 / 2L8049 TERMINAL-RING 6 GA. (NO. 10 SCREW)- / -2YNY--6-GA, NO. 10 SCREW
439F8125OEM Part NO. 9F-8125 / 9F8125 LOCKWASHER (external tooth)- / -1YYY--LOCKWASHER
445P6018OEM Part NO. 5P-6018 / 5P6018 WIRE 4.67 m(183.98 in.)- / --YYY---
453B7722OEM Part NO. 3B-7722 / 3B7722 BUSHING-REDUCING-INJECTION PUMP BLEED FLANGE & REGULATOR HOUSING- / -2YNY--REDUCING
468M2770OEM Part NO. 8M-2770 / 8M2770 CLIP .5 in. (1.27 cm) I.D. hole- / -4YYY--LOOP
472M0913OEM Part NO. 2M-0913 / 2M0913 TERMINAL (To Disconnect Switch)- / -1YYY--00-GA, 3/8-IN SCREW
483D2098OEM Part NO. 3D-2098 / 3D2098 TERMINAL ASSEM. (To Battery)- / -1YYY--POS.
498M6175OEM Part NO. 8M-6175 / 8M6175 LAMP-MINIATURE- / -4YYY---- TO BASE
503H2691OEM Part NO. 3H-2691 / 3H2691 LAMP-MINIATURE- / -1YYY---
514B1220OEM Part NO. 4B-1220 / 4B1220 SCREW .375 in. (9.53 mm) long- / -2YYY--8-32X0.375-IN
524S1988OEM Part NO. 4S-1988 / 4S1988 TERMINAL 23.5 mm(.925 in.) long- / -3YNY--14-GA TO 16-GA
536F0253OEM Part NO. 6F-0253 / 6F0253 LOCKWASHER (internal tooth)- / -1YYY--16.26MM ID
541H3338OEM Part NO. 1H-3338 / 1H3338 LOCKWASHER-TOOTH- / -4YYY--EXTERNAL TOOTH
558M5263OEM Part NO. 8M-5263 / 8M5263 CABLE ASSEM.- / -1YYY---
562D8781OEM Part NO. 2D-8781 / 2D8781 TERMINAL (Purple & White Wire)- / -2YYY--WHITE WIRE
573F9556LOCKWASHER (Internal tooth)- / -1YYY--8.4MM ID
585P4115OEM Part NO. 5P-4115 / 5P4115 WASHER-MOUNT 9W3075 FUEL LEVEL SENSOR- / -2YYY--7.2X19X2-MM THK
599B7237OEM Part NO. 9B-7237 / 9B7237 BOLT 1.25 in. (31.75 mm) long- / -1YNY--3/8-16X1.25-IN
608S0948OEM Part NO. 8S-0948 / 8S0948 CLIP (long)- / -1YYY--20.64MM ID
611H4393OEM Part NO. 1H-4393 / 1H4393 LOCKWASHER (External tooth)- / -3YYY--EXT TOOTH
623D4529OEM Part NO. 3D-4529 / 3D4529 FUSE (14 amps)- / -3YYY--14 AMP
637N4160OEM Part NO. 7N-4160 / 7N4160 SWITCH ASSEM. (heat & start)- / -1YYYNIHEAT-START
647H0027OEM Part NO. 7H-0027 / 7H0027 NUT- / -1YNY--NUT
659F9327OEM Part NO. 9F-9327 / 9F9327 SCREW (slotted-round head)- / -3YNY--10-32X0.375-IN
662L3402OEM Part NO. 2L-3402 / 2L3402 SWITCH AS. (HOUR METER-OIL PRESS. ACTIVATED)- / -1YYY--OIL PRESSURE
679D6621OEM Part NO. 9D-6621 / 9D6621 NUT (Weld)- / -1YNY--10-24-THD
682M9346OEM Part NO. 2M-9346 / 2M9346 SWITCH AS-PRESSURE (STOP LIGHTS)- / -1YYY--STOP LAMP AIR PRESS
693L6521OEM Part NO. 3L-6521 / 3L6521 TEE ENGINE BLOCK TO PRESSURE SWITCH- / -1YNY---- TO ADAPTER OR ELBOW
709B7242OEM Part NO. 9B-7242 / 9B7242 SCREW-MACHINE- / -3YNY--8-32X0.31-IN
711C0569OEM Part NO. 1C-0569 / 1C0569 BOLT (1/2 IN. LONG 5/16 IN. DIA.)- / -1YNY--5/16-18X0.5-IN
726H6756OEM Part NO. 6H-6756 / 6H6756 TERMINAL (To Buzzer-6.8 DIA. I. D)- / -1YNY--14-GA, 1/4-IN SCREW
734K5124OEM Part NO. 4K-5124 / 4K5124 CIRCUIT BREAKER (auto.-15 amp)- / -1YYY--15 AMP
740532171OEM Part NO. 053-2171 / 0532171 GROMMET JUNCTION BOX- / -1YYY--GROMMET-JUNCTION BOX
755D0853OEM Part NO. 5D-0853 / 5D0853 SCREW-MACHINE- / -2YNY--6-32-THD
769D1243OEM Part NO. 9D-1243 / 9D1243 CONNECTOR- / -1YNY---
776G2368OEM Part NO. 6G-2368 / 6G2368 BOX-FUSE- / -1YNY--FUSE
784B8626OEM Part NO. 4B-8626 / 4B8626 MACHINE SCREWS- / -1YNY---
796N5899OEM Part NO. 6N-5899 / 6N5899 TEMPERATURE SWITCH ASSEMBLY (100 DEGREES F)- / -1YYY--TEMP.
808D0389OEM Part NO. 8D-0389 / 8D0389 LAMP GROUP (stop-tail)- / -2YYYNI-
813L6306OEM Part NO. 3L-6306 / 3L6306 SWITCH ASSEM. (engine oil pressure)- / -1NYY--OIL PRESSURE
823D9872OEM Part NO. 3D-9872 / 3D9872 BUTTON--TO SWITCH PANEL ON SHIFT CONSOLE- / -1YYY--BUTTON TO SWITCH PANEL ON SHIFT CONSOLE
834D9164OEM Part NO. 4D-9164 / 4D9164 CLIP-TUBE ASSEMBLY TO BLOCK- / -2YYY---
849D1329OEM Part NO. 9D-1329 / 9D1329 HINGE ASSEM.- / -1YYYNIALARM GROUP
859B4197OEM Part NO. 9B-4197 / 9B4197 GROMMET- / -1YYY---
869D3824OEM Part NO. 9D-3824 / 9D3824 BOX- / -1YYY---
879D3821OEM Part NO. 9D-3821 / 9D3821 CABLE ASSEMBLY- / -1YYY---
885H7549OEM Part NO. 5H-7549 / 5H7549 CLIP- / -1YYY---
893D9718OEM Part NO. 3D-9718 / 3D9718 SWITCH (forward & reverse)- / -1YYY--ETHER START
906N8742OEM Part NO. 6N-8742 / 6N8742 BODY AS-DASH LAMP- / -1YYY---
917D5131OEM Part NO. 7D-5131 / 7D5131 SWITCH ASSEM. (termperature)- / -1YYY--ENG WATER TEMP
927N1062OEM Part NO. 7N-1062 / 7N1062 SWITCH ASSEM. (low air pressure)- / -2YYY--BRAKE-PRESSURE
938D7529OEM Part NO. 8D-7529 / 8D7529 WIRE ASSEMBLY- / -1YYY--WIRE ASSEMBLY
947N8597OEM Part NO. 7N-8597 / 7N8597 TERMINAL-BLADE- / -2YYY--TO SWITCH AS
959D3819OEM Part NO. 9D-3819 / 9D3819 TUBE- / -1YNY---
969D8661OEM Part NO. 9D-8661 / 9D8661 RELAY 12 VOLT- / -1YYY--RELAY
978D6812OEM Part NO. 8D-6812 / 8D6812 WIRE ASSEM.- / -2YYY---
982G8008OEM Part NO. 2G-8008 / 2G8008 COVER- / -1YNY---
992G8027OEM Part NO. 2G-8027 / 2G8027 PLATE (instruction)\1- / -1YYY---
1006G2114OEM Part NO. 6G-2114 / 6G2114 WIRE ASSEM.- / -1YYY---

Part NO. 2G8000 suitable for:

SEQPart NO.NamePos.Qty.NPRCCRServiceChangeTypeModifer

12G7616OEM Part NO. 2G-7616 / 2G7616 BATTERY AND WIRING GROUP- / -1---NI-

Parts EPC Caterpillar Parts Electric System